Isuzu D-Max vs GWM UTE

What's the difference?

The new D-Max hasn’t been majorly overhauled and instead bundles together a whole bunch of small but important changes, all of which have been designed to keep it fresh in the face of its competition, like the Triton, Ranger and HiLux.

Has it done enough? Only time will tell. But there’s little doubt that these updates only improve the D-Max formula.

Note: CarsGuide attended this event as a guest of the manufacturer, with travel, accommodation and meals provided.

In a very competitive ute market, the GWM Cannon XSR represents plenty of bang for your buck, but it’s just not as refined as you’d hope. 

It should be better at this price-point, especially when it’ll be unfavourably cross-shopped with lower-spec variants in the Ford Ranger, Isuzu D-Max and Toyota HiLux line-ups.

It’s a nice enough vehicle on-road, and the XSR is an effective 4WD on the dirt without ever being truly exceptional – but that’s fine for those who want to save big bucks and still drive away in a well-equipped twin-locked off-road vehicle.

There are some big-ish changes for this new-look D-Max, but how many of them you get depends on which of the six trim levels you’re shopping for.

Spring for one near the top of the family tree, and you’ll get all of the updates, which include new-look headlights that are LED with LED DRLs (but halogens on the SX), and a new-look front-end and grille. At the rear, there are new LED rear light clusters.

It doesn’t look a million miles away from the current D-Max, to be honest, but it does look a little newer, and a little fresher, which is important in the battle of the inches that is the new-ute market.

Inside, the brand describes the cabin as a mix of utility and comfort, and that’s feels pretty accurate from the driver’s seat.

The tech is new, with the 8.0- or 9.0-inch central screen joined by USB connection points, and there’s a new Digital Driver Display screen in the mix, along with new seat materials and trims, too.

But back to that that mix of utility and comfort. I’m not sure Isuzu has gotten the mix exactly right. There are plenty of soft-touch materials in the higher-trim levels, just not always where I want them to be.

I don’t know about you, but I like to have my elbow up when driving, and that plastic is still scratchy and hard, as is the place where my knee touches the centre console.

That said, it’s largely comfortable, definitely functional, and it serves up pretty much exactly what you might expect.

The XSR is 5439mm long (with a 3230mm wheelbase), 1958mm wide, and 1918mm high. It has a listed kerb weight of 1965kg.

It looks like the mongrel child of a HiLux, Ranger and D-Max – in a good way.

The wider-than-standard wheel track, as well as the snorkel, sports bar, substantial bash plates, tyres and even red brake calipers add to this ute’s presence.

Isuzu has taken to calling the D-Max one of Australia’s most capable utes out of the box.

That includes up to 240mm in ground clearance, 800mm in wading depth, and a towing maximum of 3.5 tonnes for the bigger diesel engine, dropping to three tonnes with the 1.9-litre powerplant fitted. Payload is up to 1405kg, too, but to get you need the SX with Cab Chassis. It’s more like 1045kg for most dual-cab ute trims.

Also new for this update is the addition of Rough Terrain Mode — a technology borrowed from the MU-X, then improved to pair with the D-Max’s mechanical off-road features.

In short, the tech taps into the traction-control systems to detect wheel slip, and can then brake individual wheels and send torque to where it is needed to smooth your progress. In the D-Max, it works with the rear diff-lock, too.

The back seat of the D-Max shows why vehicles in this category are now doubling as family vehicles. Behind my own 175cm driving position there was enough knee and headroom to get comfortable, and I’m confident you could fit three across the back row pretty easily, too.

There are some creature comforts, including a USB-C charging point (trim dependent) as well as air vents, but no temp controls, and even a little coat hook as well, but it’s not swimming with niceties.

The XSR’s five-seat interior is a neat and roomy space but, in line with most utes at this price-point, if you scrutinise it in a critical way you soon discover that some parts feel a bit cheap and flimsy, such as some buttons, dials and switches.

Up front there are two USB ports, a wireless charging pad, a 12V plug and a capacious centre console.

A pair of cupholders can be concealed under a sliding cover and the storage bin is on the right side of big.

The driver gets a six-way power-adjustable seat; the front-seat passenger gets four-way power adjustment. Both seats are comfortable without being too plush.

Second-row passengers get a firm but comfortable seat and amenities include a USB port, a 220V plug, and a fold-down centre armrest.

The second-row seat base can be folded up and out of the way to make room for more gear if only two people are travelling.

Build quality is generally okay, part from the aforementioned flimsy-feeling buttons.

The XSR’s business end, the tub, has a durable-looking tub liner, tie-down points and a handy pop-out step hidden in the top of the tailgate.

But it's worth noting this ute’s tailgate can’t be locked.

The XSR has a manufacturer suggested retail price of $52,990 drive-away.

Standard features include a 9.0-inch multimedia touchscreen system (with Apple CarPlay and Android Auto), a 7.0-inch digital driver info display, quilted leather seat trim, quilted leather door trim, 18-inch black alloy wheels, a sports bar, an assisted tailgate (with a pop-out step) and roof rails. 

It also has LED headlights with LED DRLs, side steps, powered mirrors, keyless entry, push-button start, power-adjustable and heated front seats, a leather steering wheel, single-zone climate control air conditioning, an auto-dimming rear view mirror, tinted rear glass, and a six-speaker audio system.

As well, the XSR gets a part-time 4WD system (with 2WD high-range, 4WD high-range and 4WD low-range), rather than full-time 4WD, which is on lower-spec GWM utes; a front differential lock (in addition to the existing rear diff lock) and Cooper Discoverer AT3 all-terrain tyres.

It also gets red brake calipers, an underbody bash plate, wheel arch flares, and a sunroof.

Elsewhere, it gets steel front and rear bumpers and a new black grille.

The D-Max’s powertrains for 2024 remain unchanged, with the choice of a 1.9-litre turbo-diesel four-cylinder engine good for 110kW and 350Nm, or a 3.0-litre unit producing 140kW and 450Nm. They are paired with either a six-speed manual or six-speed automatic, and two- or four-wheel drive, depending on the model.

The XSR has the Cannon’s 2.0-litre four-cylinder turbo-diesel engine that produces 120kW at 3600rpm and 400Nm from 1500rpm to 2500rpm. 

It has an eight-speed automatic transmission. 

As mentioned, the XSR has part-time 4WD – with 2WD high-range, 4WD high-range and 4WD low-range – rather than the full-time 4WD set-up that’s in standard Cannons.

Isuzu reckons you’ll see around 8.0L/100km on the combined cycle with the bigger engine, with fuel use dropping to 6.9L/100km with the 1.9-litre unit fitted.

The 76-litre tank is the same for both engines, meaning a theoretical range of 950km or 1100km.

The Cannon XSR has a listed fuel consumption of 9.4L/100km on a combined cycle.

Actual fuel consumption on this test, from pump to pump, was 11.2L/100km but, as is the nature of my testing, I did a lot of low-range four-wheel driving.

The Cannon XSR has an 78-litre tank so, going by that fuel figure above, you could reasonably expect a driving range of about 696km from a full tank.

Note: Drop 30km to 50km from any vehicle’s total calculated fuel-range figure for a better idea of that vehicle’s safe touring range – so, following that advice, the above driving range figure (696km) would become 666km after a 30km safe-distance buffer has been subtracted.

Also, remember that numerous other factors affect your fuel consumption and so impact your driving range, including how much extra weight you have onboard (passengers, camping gear, etc), whether your vehicle is fitted with any aftermarket equipment (bullbar, spare-wheel carrier, etc), whether you are towing (a camper-trailer, caravan, or boat, etc), your vehicle's tyre pressures, and the conditions.

Remember, it’s evolution over revolution for the 2024 Isuzu D-Max, so don’t expect the drive experience to be dramatically different. 

Instead, the brand says it has focused on fixing some of the complaints surrounding the outgoing model, something Isuzu is pretty open about.

It says they’ve taken feedback from the media, from their customers, and from their big fleet users, and they’ve fed it up their Japanese HQ. And the result of all that is this 2024 update.

Apparently one of the biggest complaints focused on the infotainment screen having no physical buttons, but the new one changes that with its wireless Apple CarPlay and twin USB connection points joined by a physical volume dial. I know that feels a little like you’ve taken a step backwards through time, but when something works, it works.

The’ve also made some key, and worthy, changes to the safety systems, but we will get to those in a moment.

The reality is — and I don’t mean this in an insulting way — that the new D-Max largely drives much like you might expect a top-selling diesel dual-cab to drive.

The torque on offer from both engines, but especially the bigger one, is plentiful, even if the noise of the diesel is an ever-present passenger when you put your foot down, and there is that inescapable truck-like feeling from behind the wheel.

There are some elements that set it apart, though. The steering is smooth and responsive, as is the quick-witted automatic gearbox, and despite us tipping into corners a little faster than we would on our daily commute, there wasn’t much in the way of side-to-side body roll, and no complaints from the rubber.

That might sound like I’m damning the D-Max with faint praise, but that’s not the intention. It’s a comfortable, capable, practical workhorse, and that’s ticking plenty of ute boxes, right?

The bigger-engined D-Max remains a towing powerhouse, too. We pulled some serious weight, and 3.0-litre turbo-diesel made pretty light work of it, with ample torque on offer to keep things moving.

It wouldn’t be the launch of an updated diesel dual-cab without a tour across a tailored off-road course, and Isuzu delivered, specifically to plug the merits of its new Rough Terrain Mode.

Tested back-to-back with the system switched on and off, there does seem to be less slip from the wheels when traversing bumpy, tyre-torturing articulations, with the D-Max just gripping and going. It’s another off-road tick for a ute already very good in the rough stuff.

If you’re not expecting a dynamic, sporty driving experience from the Cannon XSR, then you won’t be disappointed.

I’m enjoying the fact that off-road vehicles from China and India are improving all the time but there are significant trade-offs when opting for a much cheaper version of the ute you actually want.

The XSR is not an insubstantial ute, but that doesn’t excuse its less-than-ideal steering (which feels too loose) or its stiff ride on upgraded suspension which, even though it increases wheel travel (for 4WDing – more about that later), seemingly hasn’t been tuned to suit the XSR’s bigger tyres, wider wheel track and greater bulk than its lower-spec stablemates.

Also, this ute has an unwieldy turning circle of 13.7m, which makes it an interesting vehicle to manoeuvre along busy urban streets or through a bustling car park.

This is a well priced ute if compared to similarly equipped, much more expensive utes, but that doesn’t excuse its touchy throttle and thrashy transmission.

However, its engine, which can feel underdone when challenged, has a relaxed feel about it when open-road cruising and if you aren’t putting too much pressure on it you likely won’t think it’s much of a let-down.

Overall, the XSR does okay on sealed surfaces, without ever getting anywhere near great – it’s simply not as refined or compliant as it could – or should – be.

On the dirt track leading to our 4WD test track, the XSR was very skippy over corrugations and tended to thump through potholes.

This ute does go well off-road though when it comes time for low-range 4WDing but, equipped with front and rear diff locks, that’s to be expected.

Off-road traction control and other systems including hill descent control, are adequate without being as seamlessly smooth as the equivalent systems in more expensive vehicles.

It also has 'Crawl Mode' (allows for no-pedal, low-speed driving) and 'Turn Assist' (which brakes the XSR’s inside rear wheel to reduce the ute’s turning circle on traction-compromised surfaces).

The over-sensitive throttle is far from ideal during low-speed low-range 4WDing when you need absolute control for safe driving, but I did become used to it – or at least I put up with it.

As mentioned earlier, the upgraded suspension has boosted wheel travel, which means you’re more than likely able in the XSR to stretch a tyre to the dirt for better traction and controlled forward progress.

The XSR’s Cooper Discoverer AT3 all-terrain tyres help, especially when the dirt becomes sticky mud that would gum up a lesser tyre, and we had no strife getting up and over one of our more severe set-piece hill climbs on that rubber.

All in all, the XSR is a capable twin-locked 4WD without ever being exceptional – and that’s fine.

The Cannon XSR has towing capacities of 750kg (unbraked) and 3000kg (braked).

The Cannon range has the maximum five-star ANCAP rating from testing in 2021, however the Cannon XSR is not covered by this rating. 

Standard safety gear on the XSR includes seven airbags, AEB (sans pedestrian detection) forward collision warning, lane-departure warning, lane-keep assistance, adaptive cruise control, traffic sign recognition, rear parking sensors, a 360-degree camera and tyre-pressure monitoring.

It does not get front parking sensors, lane-change assist or a door-open warning.

The D-Max is covered by Isuzu’s six-year, 150,000km warranty, and we like the years, but less so the kilometre limits.

There’s five years of capped-price servicing, too. You’ll be visiting the service centre every 12 months or 15,000kms, and each visit will cost you $449 for the first five years, or $2245 in total.

The XSR is covered by a seven year/unlimited km warranty.

The first service is scheduled at the six-month/5000km mark (and costs $260), then every 12 months or 10,000km, with each service costing $360 a pop.