Kia Rio vs Fiat 500

What's the difference?

The Rio S Manual is a fun-to-drive little car with a big practicality and multimedia offering in a segment rapidly heading towards extinction.

While some elements of the drive experience are reminiscent of budget cars from 10-20 years ago, Kia makes up for it by wrapping the Rio in a contemporary looking and feeling package, ready for the buyer who needs no frills and demands no nonsense. Until the manual transmission goes the way of the dodo, there is almost no better option.

It feels like the Fiat 500 is coming of age in this new-generation EV form. Electric power perfectly suits this compact hatch’s unique personality. It’s comparatively well priced and the design shouts Italian cool. It’s a niche model, but the 500e’s undoubted charisma could broaden its appeal as electric vehicle adoption begins to pick up pace. 

Note: CarsGuide attended this event as a guest of the manufacturer, with travel, accommodation and meals provided.

While notable equipment is missing, the Rio reclaims lost ground with the way it looks, and to a degree, the way it feels.

Ever since this new generation hatch launched, I’ve thought it brings a slick modern design to the city-car space, and even in its most rudimentary form as-tested (our car even came in the most basic ‘Clear White’ paint) it’s a great looking little hatch.

Sure, it doesn’t have the romance factor of the Fiat 500, nor the more delicate curvature of the much more expensive new-generation Toyota Yaris, but it certainly has a more refined visage than, say, the MG3 whilst feeling a bit more grown-up than the Suzuki Swift.

Solid, squared-off lines give this car a sporty pose, and its frowny-face and blocky rear round out a stout city-car persona, and I especially like the way even this most basic trim is adorned with contrast pieces, a spoiler above the boot lid, and body-coloured door handles and mirrors.

Sure, the 15-inch steelies dress it down a bit, but on the Rio these leave the impression of financial prudence rather than cost-cutting.

Inside is basic but tidy. The overall look maintains a hint of sportiness, with an appealing symmetrical finish to the dash.

There’s no question the Rio is a budget model when it comes to the touch though, with everything either a soft polyurethane or a nasty hard plastic, so while it all might look neat it’s far from the most comfortable place to be for long periods of time.

The basic dot-matrix multifunction display, chunky plastic air-conditioning controls, and polyurethane items from the wheel to the handbrake and shifter are reminders of a bygone era, but the overall aesthetic of the driver’s space is pleasing.

In its latest electronic guise, the 500e stays loyal to its 1950s cinque­cento roots, with the addition of contemporary touches like this distinctive split headlight and DRL design, beautiful 17-inch alloys that look like they’ve come out of a jewellery box, and a simple, curved rear end treatment with classic 500-style LED tail-lights. 

There are six colours to choose from, with ‘Ice White’ being the only no-cost option.  Premium shades - ‘Onyx Black’, ‘Ocean Green’, ‘Mineral Grey’ and ‘Rose Gold’ cost $700 extra, while the ‘Tri-coat’ ‘Celestial Blue’ adds $1600 to the price.

The interior also evokes 500s of old with a familiar elongated central panel across the dash, a two-spoke steering wheel and a circular instrument binnacle. 

Woven material across the dash (made from recycled plastic) is a nice touch, and there are fun Easter eggs around the car like Turin’s skyline embossed in the wireless charging pad and an outline of the original 500 in the armrest recesses.

The single trim option is ‘Ice Beige’ synthetic leather on the seats and door panel, with a super-cool ‘FIAT’ monogram pattern, throwing back to the brand’s typography from the 1960s and ‘70s. 

Overall, the cabin design is neat and ultra-clean with a high-quality attention to detail.

I'd argue the key reason to buy the Rio at this end of the market is that it has the most space and largest cabin relative to its rivals, bar maybe the Suzuki Baleno.

All-round practicality is great, with front passengers scoring a low, sporty seating position with a high roof, and so much width in the cabin it almost feels like the Rio belongs in the next segment up.

Storage options up front include a large bottle holder and bin in each of the doors, dual cupholders next to the handbrake up front, and a large storage tray underneath the climate unit. Unlike the Yaris or Mazda2, the Rio features a small armrest console box, which gives a small lift to the ambiance of the cabin.

Back seat passengers are treated to great space for this segment, which feels nice and open courtesy of the large rear windows. At 182cm tall, I have airspace for my knees behind my own driving position, as well as relatively healthy headroom and ample width, which is again more like a car in the next segment up.

Rear passengers don’t get adjustable air vents, but there is a single USB port, a single pocket on the back of the passenger seat, and small bottle holders in each of the doors.

Perhaps the Rio’s biggest drawcard is its boot capacity, which at 325 litres is one of the largest in the city car class. Unlike the Yaris, Mazda2, or Suzuki Swift, the Rio will actually accept the CarsGuide three-piece luggage set with the rear seats up, although the rear view was obscured by the medium case.

Thanks to the boxy roofline, the Rio offers a cavernous 980L with the rear seats folded down, and despite its abundance of room, maintains a space saver spare wheel under the floor.

It might be 61mm longer than the combustion 500, but at just over 3.6m long, a little under 1.7m wide and a bit more than 1.5m tall, the 500e is still right-sized for the city.

A four-seater, it offers adequate space for the driver and front seat passenger, but with a wheelbase of just over 2.3 metres, something’s got to give, and that turns out to be room in the rear. 

Realistically, it’s a kids-only zone, and even then, those in front will need to give ground to free up some legroom. 

Storage runs to a tray between the front seats complete with roll-top lid, another storage box/armrest above that, a small glove box and bins in the doors with just enough room for a decent-size bottle. 

For connectivity, there are USB-A and USB-C ports for power and media, plus a 12V socket in the centre storage tray and another in the boot. No charging options in the back.

Speaking of the boot, it's only 185 litres (VDA) with four seats up. Enough room for a limited number of (preferably) soft bags, although the rear seat split-folds 50/50 to open up 550L.

Given the front engine, FWD configuration, it’s no surprise there’s no ‘frunk’, the 500e is a no-tow zone, and don’t bother looking for a spare of any description your only option is a repair/inflator kit.

Offered locally in a single ‘La Prima’ coupe spec the 500e is priced at $52,500, before on-road costs. Although it's available in other markets, there’s no cabriolet-style convertible for Australia this time around.

At that price point EV rivals include the entry-level ‘Classic’ version of the Mini Cooper Electric and just-released five-door Cupra Born.

And the standard features list includes a 10.25-inch multimedia display (running the latest ‘UConnect 5’ software with ‘Hey Fiat’ voice recognition), built-in navigation, a 7.0-inch digital instrument cluster, climate control air, wireless Android Auto and Apple CarPlay, a panoramic fixed glass sunroof, synthetic leather seat trim, a wireless charging pad, heated front seats and six-speaker audio with digital radio.

There’s also 17-inch alloy wheels, LED headlights, tail-lights and daytime running lights, plus keyless entry and start.

Bear in mind you’ll be adjusting the front seats manually, and the climate control is single zone, the latter not such a big deal in a small car. And the only options relate to the paint, which is detailed in the Design section.

The Rio is beginning to fall behind here with an antiquated 1.4-litre four-cylinder non-turbo petrol engine. Peak outputs aren’t far off where they should be for this segment, with 74kW of power and 133Nm of torque, although they arrive at the most distant end of the rpm range (6000rpm and 4000rpm respectively) so you need to rev it.

It can be clumsy to extract this power, too, with the engine paired in this circumstance to a six-speed manual which leaves a lot to be desired in terms of action and clutch feel.

While the abundance of ratios can be beneficial for fuel consumption, it’s clear this car was designed to be paired with the more modern three-cylinder turbocharged engine only available on the top GT-Line trim.

Power is provided by a traction electric motor sending 87kW/220Nm to the front wheels via a single-speed reduction gear automatic transmission.

It’s fed by a 42kWh lithium-ion battery, the set-up running on a 400-volt electric architecture.

The Rio S manual has an official combined cycle fuel consumption rating of 5.6L/100km, which is about right for a light car with a small engine.

On test, covering largely urban kilometres, I saw a higher but not unreasonable 7.4L/100km. Still, this number isn’t too far off what some larger cars with 2.0-litre engines are capable of.

Rios with this engine accept entry-level 91RON unleaded fuel, and have 45-litre fuel tanks. They are only compliant with Euro 5 emissions regulations.

That 42kWh battery is connected to an 85kW DC charging system, with Fiat claiming it makes 50km of range available after five minutes, and 80 per cent of range in 35 minutes.

The charging port is a CCS Type 2 combo, and the AC maximum is 11kW, taking four hours for a full charge. An 11kW Mode 3 charging cable is included as standard.

Maximum range is 311km which is pretty handy, with the benefit that the relatively small battery delivers those quick recharge times.

Energy consumption on the WLTP cycle is 14.3kWh/100km, however our relatively brief steer around Turin didn’t allow for a meaningful test figure. That will have to wait for evaluation on local soil. 

A six-speed manual with a tiny non-turbo engine is an absolute oddity in today’s new car market, but as a result of its rudimentary approach, there’s something refreshingly honest about the Rio S.

The engine requires a wringing to extract the desired result, and a lot of action on the gears, as six speeds proves to be quite a few to work your way through before you achieve cruising speed.

As so much interaction is required with the transmission, I wish it was tighter when it comes to the clutch which feels a bit doughy at the best of times.

The Rio is very organic, though, with next to no electrical assistance for any of its interaction points offering the driver a high level of control.

The steering is direct, but as a result of a cheaper rack (with less teeth compared to this car’s Stonic relation), it feels simple and brittle when it comes to feedback.

The same criticism can be levelled at the suspension, which errs on the side of firm. This attribute combines with the low seating position to make even this most basic Rio an absolute hoot in the corners.

But it can be a little crashy over every-day potholes and corrugations, despite the abundant amount of rubber cladding the 15-inch steel wheels.

Visibility is superb out of this little car’s big windows, making you feel in control of your surroundings (necessary in the multi-lane confines and tight parking conditions of a city), and ergonomics in the cabin are absolutely on-point with the large touchscreen elements easy to reach and the instruments taking a basic no-nonsense form.

While noise levels are okay at urban speeds, they pick up above 80km/h, making the Rio more unpleasant to drive over long distances than, say, the more upmarket-feeling Yaris.

The Rio does find its place in this price bracket as a fun-to-drive, but predictably rudimentary experience, for the niche audience of drivers seeking an entry-level car who are still able to shift gears themselves.

Fiat claims the 500e will dash from 0-100km/h is 9.0sec which is pretty handy, and in typical EV fashion it’s cheekily rapid around town.

Given the transmission is a single-ratio auto, the placement of buttons in the centre of the dash to control its operation makes a lot of sense. 

Acceleration is impossibly smooth, whether that’s from rest or in the cut-and-thrust of city traffic. 

There are three available drive modes. As the name implies, ‘Normal’ doesn’t place any performance limitations on the motor, while ‘Range’ shifts to more aggressive single-pedal regenerative braking and even slicker accelerator response.

Then, if you’re low on charge, ‘Sherpa’ limits maximum speed to 80 km/h and softens accelerator response while cutting the climate control and seat heaters to ensure you get to your destination in best Nepalese mountaineering fashion. 

We tried a stint in all three, and Range proved the most effective around town, the regen braking being strong but never abrupt (and able to bring you to a complete stop).  

The disc front/drum rear mechanical brakes are a bit sharp on initial bite but nice and progressive from there. 

A note for left-foot brakers, though. Apply pressure to the accelerator and brake pedals at the same time and the car bogs down in a case of minor paralysis. A quick dab on the brake is required to get things going again.  

Of course, noise levels are low, with the motor just a background hum. But Fiat has installed an unusual (mandatory) ‘Acoustic Vehicle Alert System’ warning for pedestrians at speeds up to 20 km/h.

Rather than the generic space-age tone favoured by many brands, the 500e plays the music of Amarcord by Italian composer Nino Rota. Wow. Turning the car on or off can also be set to produce a guitar sequence inside the cabin.

Suspension is strut front/torsion beam rear and over decidedly ordinary surfaces through inner Turin the 500e was impressively refined, retaining its composure over some nasty ruts and bumps. 

A roughly 300kg battery under the floor makes for a low centre of gravity, and thanks to wide tracks for its size, the 500e feels well planted and stable even in sharp cornering manoeuvres.

Steering feel is good, the 205/40 Continental EcoContact 6 rubber is agreeably quiet and grippy and a 9.7m turning circle makes reverse parking or a 180-degree change of course pretty straight forward. 

In terms of ergonomics, operating the car is stress-free with a sensible mix of on-screen and physical controls, although a minor black mark goes against small opening levers located low down in the door panels. Not exactly easy to get to.    

The Fiat 500e scored four from a maximum five stars when it was assessed by Euro NCAP in 2021, thanks in part to relatively low ratings in the ‘Vulnerable Road User’ and ‘Safety Assist’ categories.

That said, it performed well in adult and child occupant protection, and active crash-avoidance tech includes AEB (with pedestrian and cyclist detection), a reversing camera with 360-degree overhead view, ‘Intelligent Speed Assist’ (with traffic sign recognition), blind spot monitoring, lane-keeping assist, ‘Electronic Rollover Mitigation’ (manages the brakes and motor power during “extreme manoeuvres”), attention assist, tyre pressure monitoring and auto high/low beam LED headlights.

If a crash is unavoidable there are six airbags - dual front, front side, and curtains, although the increasingly prevalent front centre bag is missing in action.

There’s a back-to-base emergency call function triggered by airbag deployment, as well as top tethers and ISOFIX anchors in the two rear seat positions.