Peugeot Expert vs GWM UTE

What's the difference?

Positives are higher payload and tow ratings than the Toyota HiAce along with superior fuel economy. Negatives are inferior safety, evidence of questionable build quality and a list price more than $3000 above a HiAce equivalent. So, whether the positives outweigh the negatives to justify its higher price, only a potential buyer can decide.

In a very competitive ute market, the GWM Cannon XSR represents plenty of bang for your buck, but it’s just not as refined as you’d hope. 

It should be better at this price-point, especially when it’ll be unfavourably cross-shopped with lower-spec variants in the Ford Ranger, Isuzu D-Max and Toyota HiLux line-ups.

It’s a nice enough vehicle on-road, and the XSR is an effective 4WD on the dirt without ever being truly exceptional – but that’s fine for those who want to save big bucks and still drive away in a well-equipped twin-locked off-road vehicle.

Our 'Long' example rides on a 3275mm wheelbase with 5309mm overall length, 1920mm width and 1948mm height, so compared to the HiAce it's slightly longer in wheelbase and overall length but narrower and not as tall. It’s also significantly lighter with a kerb weight that’s almost 500kg (or half a tonne) less than the Toyota; a big factor in its spirited performance and superior payload rating.

The Peugeot’s front-wheel drive underpinnings include MacPherson strut front suspension, coil spring semi-trailing arm rear suspension, rack and pinion steering and four-wheel disc brakes. Its 12.4-metre turning circle is also more than a metre larger than the HiAce.

The Pro’s work focus can be seen in its black plastic front and rear bumpers and side mouldings where most scrapes and dents occur in hard-working vans. There’s matching black on other high-wear surfaces like the door mirrors, door handles, hubcaps, rear wipers and rego plate shroud.

The cabin has seating for three with a driver’s bucket seat and separate two-passenger bench seat. Although all occupants have ample headroom, the dashboard’s protruding centre console leaves little legroom. In fact, the centre passenger must travel with both knees skewed to the left of this extension, which then encroaches on the outer passenger’s legroom. So, for a crew of three we’d recommend short trips. Our only other criticism was the lower dash panel on the passenger’s side, which kept popping loose despite repeated attempts to click it back into place.

The XSR is 5439mm long (with a 3230mm wheelbase), 1958mm wide, and 1918mm high. It has a listed kerb weight of 1965kg.

It looks like the mongrel child of a HiLux, Ranger and D-Max – in a good way.

The wider-than-standard wheel track, as well as the snorkel, sports bar, substantial bash plates, tyres and even red brake calipers add to this ute’s presence.

Its relatively light 1743kg kerb weight combined with a 3100kg GVM allows for a sizeable 1357kg payload that’s almost 300kg more than the HiAce. It’s rated to tow up to 1800kg of braked trailer, which is also 300kg more than the Toyota. And with its 4900kg GCM, the Expert can legally tow its maximum trailer weight while carrying its maximum payload. These are excellent numbers for a multitude of working roles.

The cargo bay and cabin are separated by a stout steel bulkhead, which insulates the cabin from tyre noise emanating from the rear wheel housings and doubles as a cargo barrier. Its central window provides vision for the rear-view mirror and the ability to check on loads.

Lined to mid-height, the Expert’s cargo bay is accessed through large sliding doors on each side with handy 935mm-wide openings, while rear access is through glazed barn-doors which open to 180-degrees to aid forklift access. Each is equipped with its own windscreen wiper and demister.

The load floor is 2780mm long and 1628mm wide with 1258mm between the wheel housings, so it can carry up to three 1200 x 800mm Euro pallets or two 1165mm-square Aussie pallets, held in place by a total of eight floor-mounted load anchorage points. The 6.1 cubic metres of load volume splits hairs with the HiAce’s 6.2 cubic metres.

Cabin storage starts with a cavernous bin in the base of each front door that can easily hold a big 1.5-litre bottle and lots more. Each door also has two other compartments for smaller items. The dash-pad has a cup holder at each end and there’s a shrouded storage compartment in the centre. There are also two small storage nooks near the gearshift dial, plus on the passenger side is a glovebox and additional storage compartment (with 12V accessory plug inside).

The bench seat’s hinged base cushion also tilts forward to reveal two large storage bins below, with one thoughtfully lined with polystyrene foam to keep items either hot or cold.

The XSR’s five-seat interior is a neat and roomy space but, in line with most utes at this price-point, if you scrutinise it in a critical way you soon discover that some parts feel a bit cheap and flimsy, such as some buttons, dials and switches.

Up front there are two USB ports, a wireless charging pad, a 12V plug and a capacious centre console.

A pair of cupholders can be concealed under a sliding cover and the storage bin is on the right side of big.

The driver gets a six-way power-adjustable seat; the front-seat passenger gets four-way power adjustment. Both seats are comfortable without being too plush.

Second-row passengers get a firm but comfortable seat and amenities include a USB port, a 220V plug, and a fold-down centre armrest.

The second-row seat base can be folded up and out of the way to make room for more gear if only two people are travelling.

Build quality is generally okay, part from the aforementioned flimsy-feeling buttons.

The XSR’s business end, the tub, has a durable-looking tub liner, tie-down points and a handy pop-out step hidden in the top of the tailgate.

But it's worth noting this ute’s tailgate can’t be locked.

The XSR has a manufacturer suggested retail price of $52,990 drive-away.

Standard features include a 9.0-inch multimedia touchscreen system (with Apple CarPlay and Android Auto), a 7.0-inch digital driver info display, quilted leather seat trim, quilted leather door trim, 18-inch black alloy wheels, a sports bar, an assisted tailgate (with a pop-out step) and roof rails. 

It also has LED headlights with LED DRLs, side steps, powered mirrors, keyless entry, push-button start, power-adjustable and heated front seats, a leather steering wheel, single-zone climate control air conditioning, an auto-dimming rear view mirror, tinted rear glass, and a six-speaker audio system.

As well, the XSR gets a part-time 4WD system (with 2WD high-range, 4WD high-range and 4WD low-range), rather than full-time 4WD, which is on lower-spec GWM utes; a front differential lock (in addition to the existing rear diff lock) and Cooper Discoverer AT3 all-terrain tyres.

It also gets red brake calipers, an underbody bash plate, wheel arch flares, and a sunroof.

Elsewhere, it gets steel front and rear bumpers and a new black grille.

The Expert’s punchy 2.0-litre four-cylinder diesel is one of its strengths. Turbocharged and intercooled, it has Euro 5 emissions compliance and produces 110kW at 4000rpm and 370Nm at 2000rpm. The eight-speed torque converter automatic has near-seamless shifting and offers the choice of sequential manual-shifting using steering wheel paddle-shifters.

The XSR has the Cannon’s 2.0-litre four-cylinder turbo-diesel engine that produces 120kW at 3600rpm and 400Nm from 1500rpm to 2500rpm. 

It has an eight-speed automatic transmission. 

As mentioned, the XSR has part-time 4WD – with 2WD high-range, 4WD high-range and 4WD low-range – rather than the full-time 4WD set-up that’s in standard Cannons.

Peugeot claims a combined average consumption of 6.3L/100km and the dash display was close to that at 7.6L after 386km of testing, which included about one third of that distance carrying a full payload. Our own figure calculated from fuel bowser and tripmeter readings came in higher again at 8.3L/100km, which is still outstanding economy for a vehicle of this size. So, based on our numbers, you could expect an extensive driving range from its 70-litre tank of around 840km.

The Cannon XSR has a listed fuel consumption of 9.4L/100km on a combined cycle.

Actual fuel consumption on this test, from pump to pump, was 11.2L/100km but, as is the nature of my testing, I did a lot of low-range four-wheel driving.

The Cannon XSR has an 78-litre tank so, going by that fuel figure above, you could reasonably expect a driving range of about 696km from a full tank.

Note: Drop 30km to 50km from any vehicle’s total calculated fuel-range figure for a better idea of that vehicle’s safe touring range – so, following that advice, the above driving range figure (696km) would become 666km after a 30km safe-distance buffer has been subtracted.

Also, remember that numerous other factors affect your fuel consumption and so impact your driving range, including how much extra weight you have onboard (passengers, camping gear, etc), whether your vehicle is fitted with any aftermarket equipment (bullbar, spare-wheel carrier, etc), whether you are towing (a camper-trailer, caravan, or boat, etc), your vehicle's tyre pressures, and the conditions.

It has a comfortable driving position as the steering wheel is adjustable for height and reach, the bucket seat has a fold-down inboard armrest and there’s a prominent left footrest. Although the driver’s seat base has no rake adjustment, it’s long enough to provide good under-thigh support with enough rake to avoid sliding towards the front of it like some rivals.

The steering is responsive and nicely weighted, which combined with competent handling and braking makes the Expert feel sure-footed. The supple four-coil suspension provides a smooth unladen ride quality.

The energetic drivetrain with its 370Nm of torque has spirited acceleration and good agility in traffic. Although peak torque is at 2000rpm, the 2.0-litre turbo-diesel pulls cleanly from 1500rpm which showcases its flexibility.

The eight-speed automatic gets good results from this engine, but sequential manual-shifting using the paddle-shifters is handy when more driver input is required. The cabin is acceptably quiet at highway speeds, thanks to the cabin bulkhead and low tyre, engine and wind noise.

Our only major criticism is the absence of blind-spot monitoring and rear cross-traffic alert. In our opinion every van, particularly with solid side-walls and doors like this one, should at least have these active safety features as standard (like the HiAce which also has standard front parking sensors).

The Expert’s relatively small mirror on the passenger door is not sufficient in eliminating the large and potentially hazardous blind-spot over the driver’s left shoulder, particularly in heavy traffic and when reversing from driveways into busy streets.

If you’re not expecting a dynamic, sporty driving experience from the Cannon XSR, then you won’t be disappointed.

I’m enjoying the fact that off-road vehicles from China and India are improving all the time but there are significant trade-offs when opting for a much cheaper version of the ute you actually want.

The XSR is not an insubstantial ute, but that doesn’t excuse its less-than-ideal steering (which feels too loose) or its stiff ride on upgraded suspension which, even though it increases wheel travel (for 4WDing – more about that later), seemingly hasn’t been tuned to suit the XSR’s bigger tyres, wider wheel track and greater bulk than its lower-spec stablemates.

Also, this ute has an unwieldy turning circle of 13.7m, which makes it an interesting vehicle to manoeuvre along busy urban streets or through a bustling car park.

This is a well priced ute if compared to similarly equipped, much more expensive utes, but that doesn’t excuse its touchy throttle and thrashy transmission.

However, its engine, which can feel underdone when challenged, has a relaxed feel about it when open-road cruising and if you aren’t putting too much pressure on it you likely won’t think it’s much of a let-down.

Overall, the XSR does okay on sealed surfaces, without ever getting anywhere near great – it’s simply not as refined or compliant as it could – or should – be.

On the dirt track leading to our 4WD test track, the XSR was very skippy over corrugations and tended to thump through potholes.

This ute does go well off-road though when it comes time for low-range 4WDing but, equipped with front and rear diff locks, that’s to be expected.

Off-road traction control and other systems including hill descent control, are adequate without being as seamlessly smooth as the equivalent systems in more expensive vehicles.

It also has 'Crawl Mode' (allows for no-pedal, low-speed driving) and 'Turn Assist' (which brakes the XSR’s inside rear wheel to reduce the ute’s turning circle on traction-compromised surfaces).

The over-sensitive throttle is far from ideal during low-speed low-range 4WDing when you need absolute control for safe driving, but I did become used to it – or at least I put up with it.

As mentioned earlier, the upgraded suspension has boosted wheel travel, which means you’re more than likely able in the XSR to stretch a tyre to the dirt for better traction and controlled forward progress.

The XSR’s Cooper Discoverer AT3 all-terrain tyres help, especially when the dirt becomes sticky mud that would gum up a lesser tyre, and we had no strife getting up and over one of our more severe set-piece hill climbs on that rubber.

All in all, the XSR is a capable twin-locked 4WD without ever being exceptional – and that’s fine.

The Cannon XSR has towing capacities of 750kg (unbraked) and 3000kg (braked).

The Cannon range has the maximum five-star ANCAP rating from testing in 2021, however the Cannon XSR is not covered by this rating. 

Standard safety gear on the XSR includes seven airbags, AEB (sans pedestrian detection) forward collision warning, lane-departure warning, lane-keep assistance, adaptive cruise control, traffic sign recognition, rear parking sensors, a 360-degree camera and tyre-pressure monitoring.

It does not get front parking sensors, lane-change assist or a door-open warning.

The Expert is covered by a five years/200,000km warranty. Scheduled servicing every 12 months/20,000km whichever occurs first. Five years of capped-price servicing totals $3049 or an average of $609.80 per year.

The XSR is covered by a seven year/unlimited km warranty.

The first service is scheduled at the six-month/5000km mark (and costs $260), then every 12 months or 10,000km, with each service costing $360 a pop.