Isuzu D-Max vs Isuzu MU-X

What's the difference?

There’s a lot to like about the regular D-Max in terms of standard features, driver-assist tech, and all-round driveability – it’s an impressive 4WD with plenty of appeal as a daily driver.

And the Blade is even better – but not by a lot.

Walkinshaw’s work on the Blade has bolstered that appeal with conversion work, engineering upgrades and fitment of accessories and all of those elements are the kind of sensible changes an experienced 4WDer would usually make to their own stock-standard vehicle via the aftermarket.

And that’s a crucial point with these type of factory-modded vehicles: some people prefer to do the research, sourcing, purchasing and even the fitment of mods and accessories themselves rather than buy a ready-made adventure machine.

However, there’s no denying the convenience of a factory-backed and -accessorised 4WD ute or wagon, and Isuzu and Walkinshaw have proven, in the same way that Nissan and Premcar have, that these kinds of collaborations can yield positive results.

Do you need a Blade? No, and an LS-U+ might better suit your lifestyle. But do you want a Blade? Many a D-Max fan would say “Yes!” without hesitation.

The MU-X has always had plenty of appeal as a daily driver – dependable, not dynamic – and it’s a proven 4WD wagon.

Some people don't like the noisy, sluggish engine, but I don't mind it because it delivers off-road.

There was already a lot to like about the seven-seater wagon in terms of its off-road capability, driver-assist tech, standard features, and simple all-round driveability, and the X-Terrain – which encompasses all of that AND adds some polish to the mix – is an impressive top-shelf addition to the MU-X line-up. Even if it's so pricey...

The Blade’s distinctive look builds on the D-Max’s most recent refresh treatment, in which the ute received new headlights, a bigger grille, redesigned wheels, and three-tier LED tail-lights.

In terms of dimensions, the Blade is 5308mm long (with a 3125mm wheelbase), 1810mm high and 1910mm wide (excluding wing mirrors).

In comparison, the LS-U+ is 5285mm long (with a 3125mm wheelbase), 1790mm high and 1870mm wide (excluding wing mirrors).

So, the Blade is longer, taller, wider (with wider wheels and wheel tracks, and 23mm-wider wheel-arch flares), beefier and more imposing than its standard stablemates.

Also, at a listed kerb weight of 2204kg, this ute is 89kg heavier than the LS-U+.

Exterior Blade extras (all of these are satin black) include front grille with ‘ISUZU’ lettering (and integrated, tinted 112-watt lightbar), front bumper cladding, fender flares with integrated air curtains, ‘BLADE’ lettering across the tailgate, tailgate badging, decals on the front bar, bonnet, doors and tailgate, tubular sidesteps, and a one-piece extended sports bar with integrated stop lamp.

It also gets widened mud flaps, an individually numbered 'BLADE' identification plaque in engine bay, 'Basalt Black' tailgate and door handles and door mirrors.

Inside there are ‘BLADE’ embroidered head rests, 'BLADE’ embroidered floor mats, 'BLADE’ embossed scuff plates, and an individually numbered 'BLADE' identification plaque on the transmission selector surround.

Everything looks good, except...

This vehicle would be a whole lot more appealing without the cheesy katana-style stickers everywhere and the huge ‘BLADE’ emblazoned on its rear end. The ‘Blade’ mentions on the scuff plates and on the front-seats head-rests are about all the decoration it should have.

The decals are shaped to bring to mind the blades of samurai swords I guess, but they look more like ice hockey sticks to me – and they shouldn’t be there.

This ute would benefit from more of a subtle look – it’s chunkier-than-thou appearance speaks for itself, so there’s no need for garish tarting up of any sort.

As I’ve said before, the MU-X has never been particularly exciting or boring in terms of design, just comfortably adopting a low-key, middle-of-the-road type design – sales gold, in other words.

But the X-Terrain has distinctive ‘X’ branding here and there – inside and out – and that adds a subtle class to this variant.

The X-Terrain is 4860mm long (with a 2855mm wheelbase), 1870mm wide (excluding mirrors), 1825mm high and has a listed kerb weight of 2195kg.

It has a wheel track of 1570mm and an 11.6m turning circle. 

Our test vehicle has the exclusive X-Terrain paint – slate grey metallic – which matches well with the X badging, bigger grille design, new headlights, three-tier LED tail-lights, and redesigned wheels.

The interior strikes a stylish note as well with red stitching on the dash, centre console and leather-accented seat trim.

Isuzu could never be accused of ever sacrificing substance for style in the D-Max and that remains true in the Blade. 

Not a lot separates the LS-U+ and Blade in terms of functionality or comfort because they share essentially the same interior with only a few differences.

The interior here is at heart a workhorse’s cabin with no fancy-schmancy elements that might spoil this ute’s primary purpose: work … and a fair dose of play, of course.

The latest round of D-Max upgrades brought with it enhanced interior materials, a new 9.0-inch touchscreen multimedia system as well as upgraded functionality across all dash tech, and more charging spots for smart devices.

And the Blade treatment doesn’t add anything other than the aforementioned style tweaks to that – which is fine.

The cabin has a pleasantly familiar feel about it and it’s an easy space in which to swiftly become comfortable and to figure out where all controls are (on-screen and real switches, buttons and dials) and how to use them. 

The interior is adequately spacious with nicely supportive seats upfront and a reasonably comfortable bench-style pew for the three people at the rear. 

The Blade has leather-accented upholstery, but there are expanses of durable plastic surfaces to cope with real-life mess.

Charging options are numerous – a mix of USB-A, USB-C and 12V upfront, and USB-A for the second row – and storage places include recesses for your everyday carry gear, a suitably deep centre console, as well as dual cupholders upfront and cupholders in the fold-down armrest, and bottle holders in the doors.

Back-row passengers get USB ports, directional air-con vents and shallow under-seat storage.

The tub is 1570mm long (at floor level), 1530mm wide (1122mm between the wheel-arches) and 490mm deep. It is a double-walled tub, with an under-rail tub liner, two cargo tie-down points, and it has tailgate assist.

Tub options for D-Max owners include a tonneau or roller cover (which offers at least some degree of security from thieves, and protection from rain, mud, snow etc), or an Isuzu or aftermarket canopy, although a canopy impacts the versatility of the load space because once it’s an enclosed area it makes it more difficult to carry long, awkward and/or large loads in the tub.

The interior has a pleasant, familiar and practical feel about it and this is an easy space in which to swiftly become comfortable. 

Controls are easy to locate and operate and charging options are numerous – a mix of USB-A, USB-C and 12V up front, and USB-A for the second row.

Storage places include recesses for your everyday carry gear, a suitably deep centre console, as well as dual cupholders up front, cupholders in the rear fold-down centre armrest and bottle holders in the doors.

There are cupholders either side of the third row in the MU-X for passengers riding back there.

The MU-X has physical-button options to activate some functions (including to switch on the audio system, to adjust volume, access sat nav etc).

Seats are adequately comfortable and supportive through all three rows – yes, even the third row is roomy enough to prevent whining from whoever is stuck back there.

The cargo area is 311 litres with all three rows in use, 1119L with the third row flat and 2138L with the second and third rows folded.

The rear cargo area has a cargo cover, tie-down points, a 12V power outlet, a storage space under the rear cargo area floor and a space for tools inside the driver’s side rear cargo wall.

The MU-X X-Terrain 3.0L 4x4 is priced at $74,400 before on-road costs, or $73,990 drive-away for now.

Standard features include a 9.0-inch multimedia touchscreen system with sat-nav, wireless Apple CarPlay and Android Auto, an eight-speaker sound system, eight-way power-adjustable driver’s seat (four-way power-adjustable front passenger seat), remote engine start, smart entry and start, and 20-inch machined-alloy gloss-black wheels on 265/60R20 Bridgestone 684II HT tyres.

As part of the X-Terrain package, it has XT badging in the grille mesh, on fender and tailgate, leather-accented seats with red stitching, gloss-black fender flares and fender garnish.

It also has 265/50R20 highway terrain tyres, red ambient interior lighting with footwell lamp 360-degree, surround-view monitor, and a red-themed 7.0-inch multi-information-display.

Exterior paint jobs on the MU-X X-Terrain include four achromatic finishes: Moonstone White pearl, Mercury Silver metallic, Basalt Black mica and the new X-Terrain exclusive colour, Slate Grey metallic. 

All premium paints (pearl, metallic and mica) cost an extra $695. 

The D-Max Blade has the D-Max line-up’s 3.0-litre four-cylinder turbo-diesel engine – producing 140kW at 3600rpm and 450Nm from 1600 to 2600rpm – and it’s matched to a six-speed auto. 

Just to be clear: the Blade does not have any power or torque advantages over the standard D-Max.

This engine and auto combination form part of a proven powertrain and while this ute is sluggish when accelerating and it’s not the most dynamic vehicle to drive, the D-Max has a real tractability about it that negates most other flaws. 

It has part-time 4WD, with high- and low-range. Driver-assist tech, such as rough terrain mode, has been tweaked with the aim of making Isuzu 4WDs perform off-road even better than before.

The MU-X has a 3.0-litre four-cylinder turbo-diesel engine, producing 140kW and 450Nm and it’s matched to a six-speed auto.

These form part of a proven powertrain and while the MU-X may not be the most dynamic vehicle to drive – it’s acceleration is sluggish rather than punchy – it has a real tractability that nullifies any other niggles.

It has part-time 4WD, with high- and low-range as well as various drive modes, rough terrain mode, and a rear diff lock.

Official fuel consumption for this D-Max is 8.0L/100km on a combined cycle. 

Actual fuel consumption on this test, from pump to pump, was 10.6L/100km for the D-Max. 

The D-Max has a 76-litre fuel tank so, going by those fuel consumption figures, you should be able to get a driving range of about 717km from a full tank.

Official fuel consumption for this MU-X is 8.3L/100km and that's on a combined cycle. 

On this test I recorded 10.2L/100km. I did a lot of high and low-range four-wheel driving, so that fuel consumption is not too shabby.

The MU-X has an 80-litre fuel tank, so going by my on-test fuel consumption figures you could reasonably expect a driving range of about 784km from a full tank. 

The D-Max has never been a stand-out performer on-road in the ute segment, but it’s never been atrocious either.

The engine and auto combination yield a solid drivability rather than any liveliness, which works fine in this ute package.

Suffice to say, the D-Max is consistently middle of the pack when it comes to ride and handling or refinement comparisons, but again that suits this ute package. 

Besides, the D-Max is a body-on-frame ute with leaf spring rear suspension, so it can’t be expected to produce sportscar-like driving qualities, though the most recent upgrades to the D-Max did improve the steering and driver-assist tech.

But then came the Blade project, which wasn’t about improving the ute’s around-town driveability: Isuzu brought in the Walkinshaw Automotive Group, one of Australia’s leading automotive engineering firms, to make a version of the D-Max that was even better at off-roading than the standard unmodified D-Max.

Boiling down thousands of kilometres and man-hours of Walkinshaw’s work on the Blade into the most salient points for this yarn does not accurately reflect the effort of those involved in the years-long process … but here goes anyway: Walkinshaw has designed, engineered and remanufactured some of Australia’s most iconic nameplates, and, while the Blade reworking doesn’t introduce any new mechanical or driver-assist tech set-ups to the D-Max package, the introduction of new all-terrain tyres, wider wheel track and Aussie-tuned suspension (including Monroe 35mm MTV twin-tube dampers with lifted spring seats) has added a welcome measure of composure to this ute’s on-road behaviour.

And Isuzu big wigs must be feeling a bit chuffed at this point in time because Walkinshaw’s off-road mods have produced real results where they count most: off-road.

The standard D-Max in LS-U+ guise is an impressive 4WD ute, but the Blade version is a touch better on a variety of terrain for a number of reasons.

For starters, the Blade’s Walkinshaw-developed suspension set-up, with those 35mm twin-tube dampers in the mix, yields a more agreeable drive, with more comfort and better chassis control than a regular D-Max on fast dirt tracks and corrugated gravel roads. It manages to subdue most of the lumps and bumps you’re bound to drive over on your way to a beach- or bush-camping destination.

The Blade’s wheel track – at 1602mm, 32mm wider than the LS-U+’s 1570mm – gives this ute a slightly more planted posture than its standard stablemate for improved stability and handling.

And while the Blade’s tyres aren’t gung-ho mud-terrains or something similar, its 275/65R17 Goodyear Wrangler Duratrac RT all-terrain tyres do work sufficiently well on-road and off.

For low-range 4WDing, the Blade has all of the D-Max good stuff – including a tractable engine with plenty of low-down torque and a recalibrated off-road traction control (part of the most recent D-Max upgrades) – but its ground clearance (244mm vs the LS-U+’s 240mm) and off-road angles (29.2° approach, 19.2° departure and 25.2° breakover vs the LS-U+’s 30.5°, 19.0°, and 23.8°) don’t represent as much of an improvement over its stablemate as you’d expect in a vehicle touted by Isuzu as “an off-road ute without compromise” and “an unparalleled combination of off-road performance and rugged reliability”.

The Blade feels vulnerable to underbody knocks from rocks and the like, but it has 3mm-thick steel bash plate protection so there’s no need to lose any sleep over a few ‘rubbing dirt’ moments.

Its tubular sidesteps at least seem hardier than the standard D-Max’s sidesteps and seem able to cop knocks from rocks without crumpling.

If there’s any need for a vehicle recovery, the Blade has eight-tonne load-rated recovery points (with bracing between chassis rails for torsional rigidity) to work with.

Also, if you’re thinking about using your Blade as a touring platform, at a listed kerb weight of 2204kg, it is 89kg heavier than the LS-U+, and its payload is 896kg (down form the LS-U+’s 990kg). GVM is 3100kg, GCM is 6000kg.

Towing capacities remain at 750kg (unbraked) and 3500kg (braked).

In previous tests, the MU-X has been fine on road and more than adequate on gravel, dirt tracks, and during low-range 4WDing. But it’s been a jarring, skippy ride on irregular surfaces rather than as composed as it could – and should – have been. The culprit? Firm suspension, over-inflated tyres, too-tight trousers, who knows?

The good news is it seems like Isuzu has ironed out any issues in the suspension, minor or otherwise, because the MU-X is now is a lot better in terms of ride and handling than ever before. 

Off-road, the MU-X has always been a proven combination of its 3.0-litre, four-cylinder turbo-diesel engine, clever six-speed automatic transmission, and an off-road traction control system that's been increasingly well recalibrated through a number of generations. 

The engine is tractable and gruff, it has plenty of grunt and, as long as you're not driving like a complete hoon, you can usually get through most obstacles without a lot of fuss.

It's this mix of mechanicals and driver-assist tech that make the MU-X such an effective 4WD package. And there are a number of reasons for that. 

For one, that engine delivers plenty of torque down low and in the mid-range torque and that's crucial for four-wheel driving. 

And another thing, Rough Terrain Mode – like a beefed-up and fine-tuned off-road traction control – proves very effective because it punches torque to the wheel with the most traction – while wheel spin on tyres that aren't touching dirt is minimised – and that way it keeps the vehicle moving through obstacles with safe and controlled momentum. 

As I’ve noted before though, Rough Terrain Mode is not a magic all-conquering solution, but it is another handy addition to the MU-X’s off-road toolbox.

And the MU-X also has a rear diff lock to back you up – and that's another valuable component. 

The MU-X has approach, departure and ramp-over angles of 29.2, 26.4 and 23.1 respectively.

A listed 235mm of ground clearance is about standard for this kind of wagon but, as I’ve said before, it seems vulnerable in the underbody, side steps and its plastic mud guards. So the underbody may touch dirt, depending on how challenging the terrain is. 

Wading depth is listed as 800mm.

But, as always, with focused driving, you’ll have lots of fun and you'll minimise any superficial damage or scuff marks to the MU-X.

The MU-X has plenty of potential as a touring platform, but, if you’re planning to do any off-roading beyond well-maintained tracks, then get rid of its road-biased tyres and replace them with all-terrain tyres.

The showroom-standard tyres on this MU-X – 265/50R20 Bridgestone Dueler HTs – are okay, but not really up to scratch if tough 4WDing is what you’re keen to do. I’d prefer an 18-inch wheel and tyre package with decent all-terrains.

The MU-X has a full-sized underslung spare and in terms of packability, the MU-X X-Terrain has a listed payload of 605kg, GVM is 2800kg and GCM is 5900kg.

If you are considering using your MUX as a tow vehicle, it's handy to know that it can legally tow 750kg (unbraked) and 3500kg (braked), which is the standard for large four-wheel-drive wagons. 

Be aware though that, as with any other vehicles, once you're towing anywhere near the maximum weight, your payload is greatly reduced.

The MU-X has the maximum five-star ANCAP safety rating from testing in July 2022.

Standard safety features include eight airbags (dual front, dual seat side, dual full-length curtain, front knee and centre, far-side), and a comprehensive suite of driver-assist tech including forward collision warning, adaptive cruise control, lane departure warning, and a tyre-pressure monitoring system.

New gear onboard includes new hardware for the auto emergency braking ( AEB), like improved vehicle detection, periphery and depth perception, new digital reversing camera with a hydrophobic coating to prevent water and dirt build-up (better visibility off-road), new rear cross traffic brake (detects and reacts to approaching vehicles, cyclists, and pedestrians when reversing), as well as updated lane-keep assist ( smoother steering correction).

The D-Max has a six-year/150,000km warranty and seven years of roadside assistance when you have your D-Max always serviced at a participating Isuzu ute dealer. That warranty is okay in terms of years, but unlimited kilometres would be a welcome sweetener.

Service intervals are scheduled for every 12 months or 15,000km, whichever occurs soonest.

Capped-price servicing covers the first five scheduled services for 24MY and later vehicle models (up to five years/75,000km - whichever occurs first) – at a flat price of $449 for each service.

The MU-X has a six-year/150,000km warranty and seven years of roadside assistance. That warranty is okay in terms of years, but unlimited kilometres would be welcome.

Service intervals are scheduled for every 12 months or 15,000km, whichever occurs soonest. 

Capped-price servicing covers the first five scheduled services for 24MY and later vehicle models (up to five years/75,000km, whichever occurs first) – at a cost of $469 for each service.