Mitsubishi Outlander vs Hyundai Santa Fe

What's the difference?

The Outlander PHEV in GSR spec is a nifty daily driver, quietly appealing and more than capable of heading off-road as long as you drive it well within its AWD limits.

If you reside in the city or suburbs and your daily driving is not too punishing in terms of distance, then this PHEV makes a lot of sense. A hybrid vehicle is a happy-compromise move towards an EV future – and the Outlander PHEV is a big step in the right direction.

So I asked at the beginning if the Hyundai Santa Fe FWD petrol offered enough for families looking for a large seven-seat SUV and the answer is: YES!

It's practical, has people-mover space and storage and is downright comfortable to drive. There's so much to like here.

In terms of exterior dimensions, this PHEV is 4710mm long (with a 2706mm wheelbase), 1862mm wide and 1745mm high.

The Outlander is an inoffensive-looking AWD wagon with an appearance every bit in line with its GSR spec and price-tag without going over the top.

On the outside, this top-shelf GSR incorporates Mitsubishi’s 'Dynamic Shield' design facade, which was divisive in its early years but has since attracted its fair share of fans.

On the inside, this Outlander has black leather-appointed upholstery with silver stitching, the same treatment applied to the soft-touch armrests, centre console top, sections of the dash and elsewhere.

And the big 20-inch machined alloy wheels top off a classy yet relatively subdued overall look.

In the realm of medium-sized city-going SUVs with weekend road-trip inclinations – think Hyundai Santa Fe, Kia Sorento, Kia Sportage and the Outlander’s hybrid rivals like the Nissan X-Trail e-Power, Toyota RAV4, et al – this Mitsubishi AWD more than holds its own because in terms of design none of them are bound to set hearts a-flutter. But they’re all fine. 

It's boxy and bold and you certainly won't mistake it for anything else on the road. That's both good and bad.

The front works beautifully; pairing a chunky and square aesthetic with cool H-shaped LED headlights (a running motif throughout the car). The front and sides look like the chiseled face of a Greek hero or the latest Romantasy crush, but the rear is just awkward. It's essentially just a big blank body panel and the only interesting thing about the back are the H-shaped tail lights.

Head inside and the interior is exactly the same as the base FWD hybrid variant - you get an interesting black and grey tartan fabric upholstery across the seats, and enough soft touchpoints scattered throughout to stop you looking too hard at the heavy use of plastics.

The dashboard shares similar chunky proportions with the exterior and you can see lots of H shapes in the air vents and panelling, so it flows pretty well inside.

The highlight is 100 per cent the large curved panel on the dash that houses the dual 12.3-inch displays. They look high-end and instantly lift the cabin from feeling 'basic'.

Joinery is flush, nothing rattles and there's an overwhelming sense of high-build quality inside. It's a cabin you'll be able to spend a lot of time in.

This SUV has a family-friendly and functional interior with a premium feel, even if it does seem somewhat underdone for the price.

But it has all the right elements of a family tourer, in a cosy cabin in which it’s easy enough for driver and passengers to spend a chunk of time on lengthy road trips without complaint. I know, because we did.

The GSR has comfortable leather seats, a (mostly) user-friendly multimedia system, plenty of charge points (USB-A and USB-C up front and two USBs for second-row passengers), lots of soft-touch surfaces and a reasonable amount of storage space peppered throughout.

Nice touches, such as the heated steering wheel and heated front seats, which also have the massage function, top off what is an impressive interior.

There is wired charging for smartphones with Apple CarPlay or Android Auto, as well as a wireless charging pad. There are also 240V/1500W power outlets.

The 9.0-inch multimedia touchscreen is too small for me (perhaps a case of Old Bloke Eyes?), but it’s better when engaged in Apple CarPlay mode. The 12.3-inch high-resolution digital driver display is simple enough to use, and the 10.8-inch head-up display is a handy feature.

The driver has an eight-way power adjustable seat, so they’re able to dial-in their favourite driving position.

As stated, this Outlander’s seats are comfortable with a reasonable amount of room for everyone, though the third row is a tight fit for anyone other than children.

The second row is a 40/20/40 split configuration, while the third row is 50/50.

In terms of packing space, there is 191 litres in the rear cargo area when all seats are being used, 461 litres when the third row is folded flat, and 1387 litres when the second and third rows are stowed away.

I've said it before but I'll say it again. The cabin offers similar, if not the same, level of practicality of a people mover with passenger space and storage solutions.

In fact, Hyundai may have shot their other three-row SUV, the Palisade, in the foot here because I'm not sure why you'd now bother forking out an extra $13,800 on the base Elite grade over out test model. Not when each row will be comfortable for an adult and feature decent amenities.

With seats that don't sit too high and a 177mm ground clearance, the Santa Fe is an easy SUV to get in and out of, even for kids.

The front- and middle-row seats are the most comfortable when it comes to padding and under-thigh support. The powered drivers seat also offers adjustable lumbar support on top of the heat functions that both front seats get.

Storage is top-notch with lots of cubbies to choose from up front with dual gloveboxes, one that can fit a manual and one that will hold smaller items like a wallet, wet wipes etc.

The middle console is huge and has a removable shelf but is also shared with the middle row as the bottom pulls out into a storage drawer for them. This means you can cut out the middle man (AKA the parent) and have a handy place to put any roadie snacks.

The centre console features two phone cradles and a large shelf underneath that easily holds a handbag or Saturday night's takeaway.

There are a total of 12 cupholders (2/6/4) and four drink holders (one in each door storage bin) plus a sunglasses holder and map pockets on the back of the front seats. So, definitely spoiled for choice when it comes to individual storage.

The technology is easy to use and high-quality with display screens that feature crisp graphics and a responsive multimedia touchscreen. The system features wireless phone mirroring for Apple CarPlay and Android Auto, as well as Bluetooth connectivity.

Charging options are good throughout the car with six USB-C ports (2/2/2), and a 12-volt socket and wireless charging pad up front.

Rounding out the cabin is the large boot which offers 642L when the third row is stowed, and up to 1963L when just the front seats are in use.

The loading space is level but you still get a handy under-floor compartment for small items. And the full-size spare tyre and powered tailgate are always practical to have!

The Hyundai Santa Fe is offered in three grades, with the base- and mid-spec options now having the option of having a turbo-petrol engine or a self-charging hybrid powertrain.

Our test model is the front-wheel-drive base-petrol grade, which is priced from $53,000 before on-road costs. That makes it the most affordable variant in the Santa Fe line-up, being $2500 more affordable than the base FWD hybrid model.

This positions it in between its three-row large SUV rivals, the Kia Sorento S ($50,680) and even larger Nissan Pathfinder ST-L ($60,220). But the Sorento is still offered with a choice between V6 petrol engine and a four-cylinder turbo-diesel engine, which will entice some.

Our test model is incredibly well-equipped for a base variant and includes features like heated front seats, a powered driver's seat (with adjustable lumbar support), rear privacy glass and LED external lights.

There are great practical items like a full-size spare wheel, a powered tailgate, keyless entry/start, a 360-degree camera system, dual-zone climate control and tyre pressure monitoring.

Technology is also a standout with dual 12.3-inch displays taking centre stage, FM/AM and digital radio, wireless Apple CarPlay/ Android Auto, Hyundai 'Bluelink' app, over-the-air updates, Bluetooth connectivity, a wireless charging pad, six USB-C ports and two 12-volt sockets.

Bluelink connected car services brings features like ‘Automatic Collision Notification’ an emergency call (SOS) function, geo-fencing, valet, speed and time alerts and more.

The Outlander PHEV has a 2.4-litre four-cylinder petrol engine producing 98kW at 5000rpm and 195Nm at 4300rpm, an electric motor on the front and rear axles, and a lithium-ion battery pack with a total capacity of 20kWh.

Combined output (engine and electric motors) is 185kW and 450Nm and this PHEV’s electric-only driving range is listed as 84km on a full charge.

It has a single-speed transmission and drive modes include 'Eco', 'Normal', 'Power', 'Tarmac', 'Gravel', 'Snow' and 'Mud'.

It has three power-use settings: 'EV Mode' for low to medium speeds urban running, 'Series Hybrid Mode' which allows the petrol engine to step in for urgent acceleration or climbing hills and 'Parallel Hybrid Mode' for highway overtaking where the vehicle runs on engine power with electric assistance.

Our Santa Fe is the front-wheel-drive base variant, which features an eight-speed dual-clutch auto transmission and a 2.5-litre four-cylinder turbo-petrol engine that produces up to 206kW of power and 422Nm of torque.

Our model has a braked towing capacity of 2000kg, which is up from its hybrid siblings which can only tow up to 1650kg.

The Mitsubishi Outlander PHEV GSR has a listed fuel consumption of 1.5L/100km on a combined (urban/extra-urban) cycle but, as with all official fuel figures from any carmaker, you can take it with a hefty grain of salt.

That said, if your daily driving distances are within this PHEV’s electric driving range (84km, as listed) and you’re able to drive in EV mode most of the time, then at the very least you will have chopped your fuel bill.

On this test, dash-indicated fuel consumption was 5.8L/100km; actual fuel consumption, as measured from pump to pump, was 7.7L/100km.

The good news is the Outlander PHEV runs happily on the cheaper 91RON 'standard' fuel.

Our dash-indicated power usage was 20.8kWh/100km. This PHEV gobbled through most of its 20kWh battery capacity quite swiftly on the drive from the vehicle pick-up point in Sydney to our test start-point just over 100km away.

It recouped 10km electric driving range via regenerative braking on a series of long downhills when set to ‘Charge’ driving mode (with the combustion engine generating power to the battery), but I had to cycle through regen modes to optimise that power regain.

The dash-indicated combined driving range (battery and engine) was 748km on a full charge and a full 56-litre tank.

Mitsubishi states that if you’re charging off a standard household power point it will take “approximately” 9.5 hours to fully charge your Outlander – or 6.5 hours if you’re using a home or public charging device.

Things speed up considerably if you use a public rapid recharging station. In that case, Mitsubishi says your Outlander Plug-in Hybrid EV will reach 80 percent battery capacity in 38 minutes.

The base petrol Santa Fe has an official combined fuel cycle usage of 9.3L/100km and 67L fuel tank, giving it a theoretical driving range of 740km, which isn’t as good as its hybrid siblings but still sufficient for the odd road trip.

After doing lots of open-roading this week and a good three days of city dwelling, my real-world usage has popped out at 8.7L/100km, which is a solid result for such a large SUV.

As mentioned earlier, hybrids are your best buy at this moment in time, if you want to help save the world from climate-change disaster, avoid range anxiety, and save some money on fuel bills – all without having to sacrifice safety, comfort or features.

And – bonus – the Outlander is quite nice to drive. Not to mention a pretty handy light-duty off-roader. But more about that later.

It has a kerb weight of 2145kg with light but sharp steering and a tight (11.2m) turning circle so it’s an easy vehicle to manoeuvre around busy city and suburban streets.

The teaming of a 2.4-litre four-cylinder petrol engine and two electric motors works seamlessly well. There's always plenty of power on tap and, no matter how energetic your driving becomes, this Outlander remains smooth and quiet.

Throttle response is sharp and there’s plenty of punch off the mark as well as zippiness around town when you need it.

The PHEV’s EV-only driving range is a listed 84km but our test vehicle chewed through most of its battery power on a 110km highway trip through hilly territory.

Regenerative braking regained very little of that used power and the Outlander switched to rely on petrol for the remaining 30km or so of that trip.

The driver is able to adjust the degree of regenerative braking via paddle shifters on the back of the steering wheel: use the left to add more and the right to ease up.

The drive mode options tweak engine, electric motor, transmission and other factors to suit the selected set-up.

Other than that, ride is quite firm, handling is civilised and, overall, this Outlander is rather pleasant on sealed surfaces.

And, as I alluded to earlier, it’s surprisingly comfortable and capable off-road – as long as you stick within the parameters of the kind of 'off-road' terrain an AWD SUV is built to cope with: well-maintained gravel roads and dirt tracks with minor corrugations in dry conditions… or, at worst, rain-puddled blacktop.

The Outlander has satisfactory off-road measures for a city-focussed vehicle: of 18.3 degrees (approach angle), 22.2 degrees (departure), 18 degrees (ramp breakover) and 203mm of ground clearance (unladen). 

It feels nimble in the bush because steering is light and precise, visibility is good all-around, and the vehicle settles well on gravel and dirt tracks at speed, only ever skipping around a bit on rougher sections, due to its firm suspension and road tyres.

You can switch drives modes to either Gravel, Snow or Mud to best suit the terrain on which you’re driving but with the Outlander’s lack of ground clearance, road-biased tyres and 20-inch wheels, this SUV is hamstrung by its city-biased physicality.

But, this is still a handy dirt-road tourer, yielding comfortable and controlled ride and handling, only ever becoming rattled when the road or track surface becomes very chopped up and bumpy.

The Outlander’s 'Super-All Wheel Control' (S-AWC) system deserves a fair amount of credit. This traction control system manages torque application so it is instantaneous, and delivers drive with impressive levels of throttle control and an even-handed management of power.

Worth noting the Outlander did, of course, go through battery capacity at a faster pace off-road than it did when we were on sealed surfaces .

Off-roading, by its very nature, is more difficult and demands more of a vehicle than driving on smooth sealed surfaces does. And, for that reason – and the fact the Outlander is quite low – I’d avoid driving this SUV on terrain more challenging than well-maintained gravel roads and dirt tracks with minor corrugations in dry conditions.

I’ve driven an Outlander PHEV on sand before and it taxes the capacity even faster.

As mentioned earlier, this Outlander does not have a spare tyre. The absence of a spare – even a space-saver – is a disappointment, especially if you’re considering using your PHEV as a touring vehicle. A puncture repair kit is provided.

Payload is listed as 605kg, towing capacity is 750kg for an unbraked trailer and 1600kg braked. GVM is 2750kg and GCM is 4350kg.

The petrol engine definitely has more pep to it than the hybrid variants I've sampled. The power is responsive and you still feel like there’s heaps leftover when you have to overtake or get up a hill without any annoying engine whines.

The steering isn’t too heavy, despite the size of this car but turning off the lane-keeping aid will keep the on-road experience feeling smooth. Otherwise, you sort of ping-pong in your lane as the aid readjusts strongly.

All Santa Fes feel way more nimble than they have any right to in corners. You do get some roll, but our test model is sure-footed, even in heavy wet weather. 

The eight-speed dual-clutch auto transmission is smooth enough and you don’t get any annoying lags when you accelerate from a full stop, which is unusual for such a unit.

Ride comfort is pretty high as well, with suspension that feels forgiving over the worst of the bumps and a cabin that remains quiet, even at higher speeds. 

You have really great visibility in this model because of how big the windows are and the taller driving position helps as well. None of the pillars hindered my vision either from my driving position.

The Santa Fe well and truly fills out a car space and it was easy to see it in a car park because the butt hangs out a bit, but it’s still easy to park with its very clear 360-degree camera system and parking sensors at the front, side and rear. So while it is big, it doesn't feel big to park.

Overall, the petrol Santa Fe is an simple SUV to drive and will be a forgiving choice for lots of different driving styles.

All hybrid Hyundai Santa Fe variants are covered by a maximum five-star ANCAP safety rating from testing done in 2024, but the petrol variants are not, so our test model is currently unrated. It does feature 10 airbags, though, which is excellent for a family SUV and the curtain airbags extend to the third row.

The standard safety equipment includes blind-spot monitoring, LED daytime running lights, driver attention alert, leading vehicle departure alert, safe exit assist, rear occupant alert (first two rows only), rear collision warning, forward collision warning, rear cross-traffic alert, lane departure alert and a lane-keeping aid.

There's also lane following assist, traffic sign recognition, an intelligent seatbelt warning (first two rows only), adaptive cruise control (with start/stop), the 360-degree camera system and front, side, and rear parking sensors.

It's also nice to see the blind-spot monitor on the base model, which is a system that pops a video feed of your blind spot onto your dashboard.

However, some of the safety features, like the driver attention monitor and traffic sign recognition, can be intrusive to daily driving. If you could permanently disable the sound alert, it would be a lot more enjoyable to drive long term.

The Outlander range is covered by a 10-year/200,000km warranty – as long as servicing is completed on time by an authorised Mitsubishi dealership (otherwise, five years/100,000km) – and 10 years capped price servicing and 12 months roadside assist.

Outlander service intervals are scheduled at 12 months or 15,000km. Service costs can officially range from $349 through to $799 for a 10-year average of $549 per workshop visit.

The battery set-up has an eight-year/160,000km warranty. 

The Santa Fe comes with a five-year/unlimited-kilometre warranty, which isn’t as good as some of its rivals, especially with Nissan now offering a 10-year warranty on its models, albeit conditional.

The pre-paid servicing plans are competitive, though, and the five-year plan averages just $481 per service.

Servicing intervals could get a bit annoying if you do a lot of kays every year as they're at every 12 months or 10,000km, whichever occurs first.

The Santa Fe petrol is a simple gal and enjoys 91RON unleaded petrol and is even E10 suitable.