Mitsubishi Outlander vs Volvo XC40

What's the difference?

The Outlander PHEV in GSR spec is a nifty daily driver, quietly appealing and more than capable of heading off-road as long as you drive it well within its AWD limits.

If you reside in the city or suburbs and your daily driving is not too punishing in terms of distance, then this PHEV makes a lot of sense. A hybrid vehicle is a happy-compromise move towards an EV future – and the Outlander PHEV is a big step in the right direction.

The Volvo XC40 Recharge Twin Motor is a cute small electric SUV that offers a decent specs list and a sweet urban driving experience. It’s not the nicest ride on a longer journey but it does have a decent range to be able to tackle one, if needed. I didn’t love the interior design but there’s lots the XC40 gets right.

In terms of exterior dimensions, this PHEV is 4710mm long (with a 2706mm wheelbase), 1862mm wide and 1745mm high.

The Outlander is an inoffensive-looking AWD wagon with an appearance every bit in line with its GSR spec and price-tag without going over the top.

On the outside, this top-shelf GSR incorporates Mitsubishi’s 'Dynamic Shield' design facade, which was divisive in its early years but has since attracted its fair share of fans.

On the inside, this Outlander has black leather-appointed upholstery with silver stitching, the same treatment applied to the soft-touch armrests, centre console top, sections of the dash and elsewhere.

And the big 20-inch machined alloy wheels top off a classy yet relatively subdued overall look.

In the realm of medium-sized city-going SUVs with weekend road-trip inclinations – think Hyundai Santa Fe, Kia Sorento, Kia Sportage and the Outlander’s hybrid rivals like the Nissan X-Trail e-Power, Toyota RAV4, et al – this Mitsubishi AWD more than holds its own because in terms of design none of them are bound to set hearts a-flutter. But they’re all fine. 

The XC40 Recharge sees some design changes from its fuel-based counterparts and that’s mainly seen in the front because you get a body-coloured panel instead of a standard grille. The 20-inch alloys feature a chunkier-looking design but the front still boasts the cool ‘Hammer of Thor’ headlights (which I'm rather fond of).

The interior is where the electric powertrain loses me because the fuel-based equivalent is so much nicer inside with its leather-accented upholstery and trims.

It's lovely that there has been a conscious effort to use recycled materials and non-leather upholstery throughout but I'm left with the strange-feeling that synthetic seats don’t reflect the grade or price level of this car. 

Other than the cool-looking topography inserts on the dash and front doors and the 9.0-inch vertical multimedia system, it’s pleasant but a little basic in the cabin. Which is shame because the exterior is cute as hell.

This SUV has a family-friendly and functional interior with a premium feel, even if it does seem somewhat underdone for the price.

But it has all the right elements of a family tourer, in a cosy cabin in which it’s easy enough for driver and passengers to spend a chunk of time on lengthy road trips without complaint. I know, because we did.

The GSR has comfortable leather seats, a (mostly) user-friendly multimedia system, plenty of charge points (USB-A and USB-C up front and two USBs for second-row passengers), lots of soft-touch surfaces and a reasonable amount of storage space peppered throughout.

Nice touches, such as the heated steering wheel and heated front seats, which also have the massage function, top off what is an impressive interior.

There is wired charging for smartphones with Apple CarPlay or Android Auto, as well as a wireless charging pad. There are also 240V/1500W power outlets.

The 9.0-inch multimedia touchscreen is too small for me (perhaps a case of Old Bloke Eyes?), but it’s better when engaged in Apple CarPlay mode. The 12.3-inch high-resolution digital driver display is simple enough to use, and the 10.8-inch head-up display is a handy feature.

The driver has an eight-way power adjustable seat, so they’re able to dial-in their favourite driving position.

As stated, this Outlander’s seats are comfortable with a reasonable amount of room for everyone, though the third row is a tight fit for anyone other than children.

The second row is a 40/20/40 split configuration, while the third row is 50/50.

In terms of packing space, there is 191 litres in the rear cargo area when all seats are being used, 461 litres when the third row is folded flat, and 1387 litres when the second and third rows are stowed away.

Front passengers enjoy the most space and I have plenty of head- and legroom up front. It’s a really easy car to get in and out of and the individual storage is very good for the class. 

Front passengers enjoy a glove box, middle console with a removeable bin, two cupholders, utility tray and skinny drink bottle holders in the storage bins in the doors.

In the rear, passengers get map pockets on the backs of the front seats, two cupholders in the fold-down armrest and small storage bins in each door.

The synthetic leather-trimmed seats look neat and tidy but are very hard in the cushion, which makes them a tad uncomfortable on longer trips. The rear seats are much the same.

Charging options throughout the car are good with the front enjoying a 12-volt port, two USB-C sockets and a wireless charging pad to choose from. The rear also gets two USB-C ports and there's another 12-volt outlet in the boot.

The rest of the technology is easy to use once you spend some time with it. The 9.0-inch touchscreen multimedia system features built-in Google Maps, Assistant and Play Store apps, as well as, YouTube.

The 12.0-inch digital instrument panel isn’t customisable but I like the way it pulls through the satellite navigation screen and directions.  

Because of the dual-motor powertrain, your boot capacity drops to 419L from 452L for the single-motor variant. It is large enough for my grocery shop and random errands and you can fold the floor up to create a deep storage well for additional space. Fold the 60/40 split-folding rear seat and available space expands to 1295 litres.

I don’t like the hardened cargo liner, it feels and looks a little cheap, but I do like the powered tailgate. There’s also handy frunk storage of 31L, which is perfectly sized for any charging cables you will have.

There are two powertrain options in the XC40 family, a mild-hybrid or pure electric. The latter gets two variants and we’re in the top-spec Recharge Twin Motor, which is priced from $85,990, before on-road costs. This positions it in the middle of its nearest rivals but in its family line-up it’s a big $23K jump from its Ultimate B4 AWD combustion equivalent.

The standard features list for the XC40 is robust and there are some great premium features, like the electrically-adjustable and heated front seats with extendable under-thigh support and electric lumbar control.

A panoramic sunroof makes the cabin feel light and airy, the rear outboard seats have heat functions and the driver enjoys a heated steering wheel. You also get a premium 13-speaker Harman Kardon sound system in the Twin Motor.

Other premium features include pre-entry and after-park climate control (perfect for those super-hot days) and a hands-free powered tailgate.

Technology highlights include a complimentary four-year subscription for the built-in Google Assistant, Google Maps and Google Play Store which are accessed via the portrait-style 9.0-inch multimedia touchscreen.

There's also access to apps like YouTube, which delighted my seven-year old and would be handy on any charging stints for some diversion. It's surprising there isn't wireless functionality for Apple CarPlay and Android Auto but they can be hooked up via cable.

The Outlander PHEV has a 2.4-litre four-cylinder petrol engine producing 98kW at 5000rpm and 195Nm at 4300rpm, an electric motor on the front and rear axles, and a lithium-ion battery pack with a total capacity of 20kWh.

Combined output (engine and electric motors) is 185kW and 450Nm and this PHEV’s electric-only driving range is listed as 84km on a full charge.

It has a single-speed transmission and drive modes include 'Eco', 'Normal', 'Power', 'Tarmac', 'Gravel', 'Snow' and 'Mud'.

It has three power-use settings: 'EV Mode' for low to medium speeds urban running, 'Series Hybrid Mode' which allows the petrol engine to step in for urgent acceleration or climbing hills and 'Parallel Hybrid Mode' for highway overtaking where the vehicle runs on engine power with electric assistance.

The XC40 Recharge Twin Motor features two electric motors which are powered by a large 82kWh lithium-ion battery and produce a combined power output of 300kW and 670Nm of torque.

Which is downright fun because it can do a 0-100km/h sprint in just 4.8-seconds!

The Mitsubishi Outlander PHEV GSR has a listed fuel consumption of 1.5L/100km on a combined (urban/extra-urban) cycle but, as with all official fuel figures from any carmaker, you can take it with a hefty grain of salt.

That said, if your daily driving distances are within this PHEV’s electric driving range (84km, as listed) and you’re able to drive in EV mode most of the time, then at the very least you will have chopped your fuel bill.

On this test, dash-indicated fuel consumption was 5.8L/100km; actual fuel consumption, as measured from pump to pump, was 7.7L/100km.

The good news is the Outlander PHEV runs happily on the cheaper 91RON 'standard' fuel.

Our dash-indicated power usage was 20.8kWh/100km. This PHEV gobbled through most of its 20kWh battery capacity quite swiftly on the drive from the vehicle pick-up point in Sydney to our test start-point just over 100km away.

It recouped 10km electric driving range via regenerative braking on a series of long downhills when set to ‘Charge’ driving mode (with the combustion engine generating power to the battery), but I had to cycle through regen modes to optimise that power regain.

The dash-indicated combined driving range (battery and engine) was 748km on a full charge and a full 56-litre tank.

Mitsubishi states that if you’re charging off a standard household power point it will take “approximately” 9.5 hours to fully charge your Outlander – or 6.5 hours if you’re using a home or public charging device.

Things speed up considerably if you use a public rapid recharging station. In that case, Mitsubishi says your Outlander Plug-in Hybrid EV will reach 80 percent battery capacity in 38 minutes.

The official energy consumption figure is 19kWh/100km and I averaged 19.2kWh over a fair mix of urban and open-road driving. The energy consumption isn't bad but some rivals do sit closer to that 16.5kWh mark.

The official driving range is up to 485km for this model but I only ever saw a top range of 410km. That's not terribly surprising given I wasn't shy with the power use but there was a little bit of range anxiety on longer trips.

The XC40 Recharge Twin Motor has a Type 2 CCS charging port which means you can benefit from faster charging speeds. On an 11kW AC charger you can go from 0-100 per cent in eight hours but on a standard three-pin house plug socket expect that wait time to go up significantly.

On a DC fast charger expect to go from 10-80 per cent in as little as 33-minutes.

As mentioned earlier, hybrids are your best buy at this moment in time, if you want to help save the world from climate-change disaster, avoid range anxiety, and save some money on fuel bills – all without having to sacrifice safety, comfort or features.

And – bonus – the Outlander is quite nice to drive. Not to mention a pretty handy light-duty off-roader. But more about that later.

It has a kerb weight of 2145kg with light but sharp steering and a tight (11.2m) turning circle so it’s an easy vehicle to manoeuvre around busy city and suburban streets.

The teaming of a 2.4-litre four-cylinder petrol engine and two electric motors works seamlessly well. There's always plenty of power on tap and, no matter how energetic your driving becomes, this Outlander remains smooth and quiet.

Throttle response is sharp and there’s plenty of punch off the mark as well as zippiness around town when you need it.

The PHEV’s EV-only driving range is a listed 84km but our test vehicle chewed through most of its battery power on a 110km highway trip through hilly territory.

Regenerative braking regained very little of that used power and the Outlander switched to rely on petrol for the remaining 30km or so of that trip.

The driver is able to adjust the degree of regenerative braking via paddle shifters on the back of the steering wheel: use the left to add more and the right to ease up.

The drive mode options tweak engine, electric motor, transmission and other factors to suit the selected set-up.

Other than that, ride is quite firm, handling is civilised and, overall, this Outlander is rather pleasant on sealed surfaces.

And, as I alluded to earlier, it’s surprisingly comfortable and capable off-road – as long as you stick within the parameters of the kind of 'off-road' terrain an AWD SUV is built to cope with: well-maintained gravel roads and dirt tracks with minor corrugations in dry conditions… or, at worst, rain-puddled blacktop.

The Outlander has satisfactory off-road measures for a city-focussed vehicle: of 18.3 degrees (approach angle), 22.2 degrees (departure), 18 degrees (ramp breakover) and 203mm of ground clearance (unladen). 

It feels nimble in the bush because steering is light and precise, visibility is good all-around, and the vehicle settles well on gravel and dirt tracks at speed, only ever skipping around a bit on rougher sections, due to its firm suspension and road tyres.

You can switch drives modes to either Gravel, Snow or Mud to best suit the terrain on which you’re driving but with the Outlander’s lack of ground clearance, road-biased tyres and 20-inch wheels, this SUV is hamstrung by its city-biased physicality.

But, this is still a handy dirt-road tourer, yielding comfortable and controlled ride and handling, only ever becoming rattled when the road or track surface becomes very chopped up and bumpy.

The Outlander’s 'Super-All Wheel Control' (S-AWC) system deserves a fair amount of credit. This traction control system manages torque application so it is instantaneous, and delivers drive with impressive levels of throttle control and an even-handed management of power.

Worth noting the Outlander did, of course, go through battery capacity at a faster pace off-road than it did when we were on sealed surfaces .

Off-roading, by its very nature, is more difficult and demands more of a vehicle than driving on smooth sealed surfaces does. And, for that reason – and the fact the Outlander is quite low – I’d avoid driving this SUV on terrain more challenging than well-maintained gravel roads and dirt tracks with minor corrugations in dry conditions.

I’ve driven an Outlander PHEV on sand before and it taxes the capacity even faster.

As mentioned earlier, this Outlander does not have a spare tyre. The absence of a spare – even a space-saver – is a disappointment, especially if you’re considering using your PHEV as a touring vehicle. A puncture repair kit is provided.

Payload is listed as 605kg, towing capacity is 750kg for an unbraked trailer and 1600kg braked. GVM is 2750kg and GCM is 4350kg.

Like the Polestar 2 there’s no ignition button on the XC40. You shift into drive to ‘turn on’ and after you park, you simply get out to turn it off. It takes a little while to get used to but it’s a cool feature. 

The twin motors deliver a hefty kick and you never worry about not having ‘enough power’. In the city it’s zippy but on the open-road you also feel comfortable getting up to speed or overtaking because the power distribution is so well-balanced because it’s an AWD.

I customised my steering wheel ‘feel’ to firm and it makes the handling crisp and direct. You feel like you’re in total control whenever you have to tackle be it tight streets or small car parks.

The blind-spot visibility is compromised by how wide the B and C-pillars are and I find that I'm relying a lot more on the blind-spot monitoring system to compensate.

The XC40 loses a few points for me in terms of ride comfort. As mentioned, the seats aren't terribly comfortable but the suspension is hard enough that you notice every bump, as well.

Road noise is also quite pronounced and it doesn’t sound refined when you drive at higher speeds, which is a shame. The flip-side, though, is that you don’t notice those things as much on short, urban trips.

The standard regen braking isn’t customisable and you don’t notice it until you switch over to a 'one-pedal' function. I found this function uncomfortable to use as it’s very aggressive and creates a jerky driving experience. 

Because of its 4440mm length and tiny 11m turning circle, you won’t struggle in a car park! The 360-degree view camera system and front and rear parking sensors make it easy to navigate a tight spot.

This is a joy to park. It’s so easy.

The XC40 has a long safety features list but a standout is the Volvo designed 'Side Impact Protection System' (SIPS) that reinforces the car's steel framework at the sides and disperses energy in a side collision.

Other standard features include full LED external lights, daytime running lights, adaptive cruise control, rear cross-traffic alert, blind-spot monitoring, driver attention alert, forward collision warning, lane departure alert, lane keeping aid, intelligent seatbelt reminders, traffic sign recognition, 360-degree camera system, front and rear parking sensors.

The XC40 has a maximum five-star ANCAP safety rating from testing done in 2018. It has seven airbags, including a driver's knee bag and features high individual scoring for adult and child occupant protection at 97 per cent and 84 per cent, respectively. 

The XC40 has AEB with car, pedestrian and cyclist detection and is operational from 4.0-210km/h. It's usual to see that top speed sit closer to 180km/h, so that's very good.

A cool feature for any parents out there is the second key which you can program to limit stereo volume levels and set a maximum speed allowance. It's even coloured bright orange so there are no chances of a sneaky switcheroo!

There are ISOFIX child-seat mounts on the rear outboard seats and three top-tether anchor points for any families out there but two seats will fit best.

The Outlander range is covered by a 10-year/200,000km warranty – as long as servicing is completed on time by an authorised Mitsubishi dealership (otherwise, five years/100,000km) – and 10 years capped price servicing and 12 months roadside assist.

Outlander service intervals are scheduled at 12 months or 15,000km. Service costs can officially range from $349 through to $799 for a 10-year average of $549 per workshop visit.

The battery set-up has an eight-year/160,000km warranty. 

The ongoing costs are pretty solid with the XC40 coming with a usual five-year/ unlimited warranty term but the drive battery is covered for eight years/160,000km.

You can pre-purchase a five-year/150,000km servicing program for a flat $3000 or an average of $600 per service, which is a bit expensive for the class. Servicing intervals are great at every two-years or 30,000km, whichever occurs first.

You get complimentary roadside assistance for five-years through Assist Australia and if you meet certain criteria, you can extend that by a further three years, which is handy.